World Library  
Flag as Inappropriate
Email this Article

China Airlines Flight 006

China Airlines Flight 006
Damage to N4522V's horizontal stabilizers after it experienced a free fall of 30,000 ft.
Incident summary
Date 19 February 1985
Summary Crew disorientation, pilot error, Number 4 engine flameout.
Site Pacific Ocean, near San Francisco, California, United States
Passengers 251
Crew 23
Injuries (non-fatal) 24 (2 serious)
Survivors 274 (all)
Aircraft type Boeing 747SP-09
Operator China Airlines
Registration N4522V
Flight origin Chiang Kai Shek Int'l Airport
Destination Los Angeles Int'l Airport

China Airlines Flight 006 (callsign "Dynasty 006") is a daily non-stop flight from Taipei to Los Angeles International Airport. On February 19, 1985, it was involved in an aircraft upset accident after the No. 4 engine flamed out. The plane rolled over and plunged 30,000 ft (9,100 m), experiencing high speeds and g-forces (approaching 5g) before the captain was able to recover from the rapid dive, and then to divert to San Francisco International Airport.[1]


  • Incident 1
  • Aftermath 2
  • In popular culture 3
  • Footnotes 4
  • External links 5


N4522V, the aircraft involved in the incident

The accident occurred ten hours into the service that departed Tapei at 16:15. The Boeing 747SP-09 was 350 miles (550 km) northwest of San Francisco, cruising at an altitude of 41,000 ft (12,500 m). The flight was in the hands of a seasoned crew, consisting of Captain Min-Yuan Ho (55), First Officer Ju Yu Chang (53), Flight Engineer Kuo-Win Pei (55), Relief Captain Chien-Yuan Liao (53), and Relief Flight Engineer Po-Chae Su Shih Lung (41).[1] Captain Ho was a highly experienced pilot with approximately 15,500 flight hours. The first officer was also experienced, with more than 7,700 hours to his credit, and the flight engineer, like the captain, had approximately 15,500 hours of flight time.[2] The incident occurred while the main crew was on duty.

N4522V at Tijuana International Airport in 2009.

The sequence began when the No. 4 (starboard outermost) engine stalled at a low thrust setting and flamed out. That engine had failed twice during previous flights (while cruising at FL 410 and 430). In each of those cases, the engine was restarted after descending to a lower altitude. The maintenance response to the logbook entries that noted the problems included engine inspection, fuel filter drainage and replacement, vane controller inspection and replacement, water drainage from Mach probes, insufficient modules, and other filter replacements. None of those acts fixed the recurrent stalling and flameout problem of the No. 4 engine.[1][3]

Diagram of aircraft roll/pitch attitudes and time from the NTSB report

After the flameout, the captain instructed the flight engineer to attempt to restart the engine, while the plane remained at FL 410 (41,000 feet) with the autopilot still engaged and the bleed air on. This was contrary to the flight manual procedure, which required the plane to be below 30,000 feet (9,100 m) before any attempt to restart a flamed-out engine. The attempt failed.

The airspeed continued to decrease, while the autopilot rolled the control wheel to the maximum left limit of 23 degrees. As the speed decreased even further, the plane began to roll to the right, even though the autopilot was maintaining the maximum left roll limit. By the time the captain disconnected the autopilot, the plane had rolled over 60 degrees to the right and the nose had begun to drop. Aileron control was the only means available to the autopilot to keep the wings level as the autopilot does not connect to the rudder during normal cruise flight. To counteract the asymmetrical forces created by the loss of thrust from the No. 4 engine, it was essential for the pilot to manually push on the left rudder. However, the captain failed to use any rudder inputs at all, before or after disconnecting the autopilot. The resulting uncontrolled flight path is depicted in the diagram.

As the plane descended through clouds, the captain's attention was drawn to the artificial horizon which displayed excessive bank and pitch. Because such an attitude is highly irregular, the crew incorrectly assumed the indicators to be faulty. Without any visual references (due to the clouds) and having rejected the information from the ADIs, the crew became spatially disoriented. The plane entered a steep dive at a high bank angle. Altitude decreased 10,000 ft (3,000 m) within only 20 seconds, a vertical descent averaging 30,000 feet per minute (150 m/s). The crew and passengers experienced g-forces reaching as much as 5g.[1]

Only after breaking through the bottom of the clouds at 11,000 feet (3,400 m) did the captain orient himself and bring the plane under control, leveling out at 9,600 feet (2,900 m). They had descended 30,000 ft (9,100 m) in under two and a half minutes. The flight crew were under the impression that all four engines had flamed out, but the National Transportation Safety Board believes only engine No. 4 had failed. After leveling out, it was found that the three remaining engines were supplying normal thrust. A restart attempt brought No. 4 back into use. They began climbing and reported to air traffic control "condition normal now" and they were continuing on to Los Angeles. They then noticed that the inboard main landing gear was down[1] and one of the plane's hydraulic systems was empty. Because they did not have sufficient fuel to reach Los Angeles with the drag added by the landing gear, they diverted to San Francisco. Learning there were injured people on board, an emergency was declared and they flew straight in to the airport and landed without further incident.


There were two serious injuries on board: a fracture and laceration of a foot, and an acute back strain requiring two days of hospitalization. The aircraft was significantly damaged by the aerodynamic forces. The wings were permanently bent upwards by 2 inches (50 mm), the inboard main landing gear lost two actuator doors, and the two inboard main gear struts were left dangling.[1] Most affected was the tail, where large outer parts of both horizontal stabilizers had been ripped off. The entire left outboard elevator had been lost along with its actuator, which had been powered by the hydraulic system that ruptured and drained.

After substantial investigation, this accident brought to international attention the problem of pilots suffering jet lag as a contributing factor to pilot errors. The captain was considered to be an experienced pilot and had flown six international flights in the previous two weeks. Though he testified that he did not believe he was tired, NTSB investigators suggest that his inability to sleep during his rest period and the fact that the accident took place at 2 am Taipei time contributed to his inability to focus on and process important details about the aircraft's behavior that could have averted the accident.

After repairs were made to correct the significant damage to the plane, it returned to service on April 25, 1985. It continued in service for nearly 12 years until it was leased to China Airlines' sister company, K. A. Paul, and was christened 'Global Peace One'. On July 17, 2005 the FAA suspended its operating certificate due to insufficient maintenance. It was then due for major maintenance work, which was never completed. As of May 20, 2010, the aircraft is kept in a large hangar at General Abelardo L. Rodríguez International Airport in Tijuana, Baja California, and it is possible that it will be scrapped as it is reported to be in very poor condition.[3] The aircraft can be seen using Google Earth at the coordinates .

In popular culture

  • The flight was documented on an episode of the television program Mayday (otherwise known as Air Emergency or Air Crash Investigation) titled "Panic Over the Pacific".


  1. ^ a b c d e f NTSB report courtesy of University of Bielefeld - Faculty of technology html version by Hiroshi Sogame Safety Promotion Comt. All Nippon Airways
  2. ^
  3. ^ a b [1]

External links

  • Accident Brief by the U.S. National Transportation Safety Board.
  • Full Accident Report by the U.S. National Transportation Safety Board.
  • Summary and comments in Risks Digest.
  • Time Magazine story
  • German article with pictures of the damaged airplane after landing in Der Spiegel
This article was sourced from Creative Commons Attribution-ShareAlike License; additional terms may apply. World Heritage Encyclopedia content is assembled from numerous content providers, Open Access Publishing, and in compliance with The Fair Access to Science and Technology Research Act (FASTR), Wikimedia Foundation, Inc., Public Library of Science, The Encyclopedia of Life, Open Book Publishers (OBP), PubMed, U.S. National Library of Medicine, National Center for Biotechnology Information, U.S. National Library of Medicine, National Institutes of Health (NIH), U.S. Department of Health & Human Services, and, which sources content from all federal, state, local, tribal, and territorial government publication portals (.gov, .mil, .edu). Funding for and content contributors is made possible from the U.S. Congress, E-Government Act of 2002.
Crowd sourced content that is contributed to World Heritage Encyclopedia is peer reviewed and edited by our editorial staff to ensure quality scholarly research articles.
By using this site, you agree to the Terms of Use and Privacy Policy. World Heritage Encyclopedia™ is a registered trademark of the World Public Library Association, a non-profit organization.

Copyright © World Library Foundation. All rights reserved. eBooks from World eBook Library are sponsored by the World Library Foundation,
a 501c(4) Member's Support Non-Profit Organization, and is NOT affiliated with any governmental agency or department.